Layed NQ50 over

scooby26t · Post by **scooby26t** » Sun May 03, 2009 7:16 pm

I was wondering if anyone could help me. I layed my scooter over. Now since that has happened the scooter runs fine untill it gets warmed up. After that it dies. It also stutters after you start going down the road. Can anyone give me odeas on how to fix this problem I would like to get it back on the road. Summertime is comming. THANKS

Post by **noiseguy** » Sun May 03, 2009 10:09 pm

Which side did you drop? Did you knock the aircleaner pipe off?

scooby26t · Post by **scooby26t** » Mon May 04, 2009 4:15 pm

I layed it over on to the left side. You know I did not even think to look at the aircleaner pipe. I will look tonight and see if that is the problem. I will let you know.

scooby26t · Post by **scooby26t** » Mon May 04, 2009 4:17 pm

forgot to report the scooter made it out better than I did. only got a few scratches and the problems. But I ended up with a broke finger and in a cast for 4-6 weeks.

bradthreee · Post by **bradthreee** » Mon May 04, 2009 5:18 pm

Aw mang that really sucks! You must have been flying!

scooby26t · Post by **scooby26t** » Mon May 04, 2009 9:03 pm

was going about 25 when I hit the stones. Also checked the air cleaner tube and it is still connected. Anyone got any ideas PLEASE HELP

Post by **noiseguy** » Mon May 04, 2009 11:17 pm

You need to pull and clean the carb, sounds like a dirty idle jet.

scooby26t · Post by **scooby26t** » Wed May 06, 2009 7:36 pm

Ok cleaned the carb and now it will not stay running under throttle. I tried to clean the carb again and it does the same thing. As soon as you give it any type of throttle it dies. HELP.

evilone · Post by **evilone** » Wed May 06, 2009 7:53 pm

Clean carb 5 more times

Kenny_McCormic · Post by **Kenny_McCormic** » Wed May 06, 2009 8:03 pm

evilone wrote:Clean carb 5 more times

Yep, use Dacs guide.

evilone · Post by **evilone** » Wed May 06, 2009 8:15 pm

I can't find the post, but pay close attention to the small hole in the carb bowl and make sure it's clear. If you layed it down and dis-logged a small piece of whatever it can clog that hole easy. Take bowl in a dark room and shine flashlight down the "tube" in the bowl and see if you can see a small light in the bowl. You can use a wire from a wire brush to clear it, that's how small it is. But...i'm not sure if this affects idle, maybe someone could chime in and clarify it.

Post by **noiseguy** » Wed May 06, 2009 9:21 pm

scooby26t wrote:Ok cleaned the carb and now it will not stay running under throttle. I tried to clean the carb again and it does the same thing. As soon as you give it any type of throttle it dies. HELP.

If it now idles but is dying on throttle, you have a break in the airbox somewhere. They do this when either the airbox is disconnected, or the main jet is blocked, OR if you have a bad vacuum leak.

jstone · Post by **jstone** » Wed May 06, 2009 9:28 pm

No questions about the bystarter being broke?

Kenny_McCormic · Post by **Kenny_McCormic** » Wed May 06, 2009 10:22 pm

Tear the intake side down to the reedblock.Maybe you cracked your manifold. also check the exhaust system.

scooby26t · Post by **scooby26t** » Thu May 07, 2009 9:07 pm

Ok everyone sounds like I got some work ahead of me. Guess it will have wait till the hand is healed because I had the wife help with the carb cleaning. Not sure she will want to get into all this. Will report back soon hopefully with some good news.